How much does electrical panel upgrade cost in Aurora, IL?

Most Aurora homeowners spend between $1,900 – $4,750 on electrical panel upgrade, with an average around $3,050. Local labor prices 6% above the national average, so Aurora quotes tend to land at the higher end of national ranges.

Why is electrical panel upgrade more or less expensive in Aurora than elsewhere?

Aurora is one of the more affordable Chicago-area submarkets. Snow loads and freeze-thaw cycles affect roofs and driveways.

Do I need a permit for electrical panel upgrade in Aurora, Illinois?

City permits required for exterior and structural work. Always confirm current requirements with the local building department before signing a contract, and make sure the permit is pulled by your licensed contractor.

How many quotes should I get in Aurora?

Get at least three written quotes from licensed, insured Illinois contractors. Comparing line items — not just the bottom line — is the fastest way to spot an inflated bid in the Chicago market.

How much does a 200 amp panel upgrade cost?

$2,000 to $4,500 typically, or $2,800 to $6,000 if the meter base and service entrance also need replacing.

How long does a panel upgrade take?

One day for the electrical work, with power out four to eight hours. Utility scheduling and inspection may spread it over a few days.

Do I need 200 amps for an EV charger?

Usually. A Level 2 charger draws 40 to 60 amps; most 100 amp services cannot support it without load management.

Is a permit required?

Always. The utility will not reconnect without an inspection sign-off, and unpermitted work surfaces during a home sale.

What are Federal Pacific and Zinsco panels?

Obsolete panels with breakers that fail to trip. Insurers often refuse coverage and replacement is strongly recommended regardless of capacity.

Can I just add a subpanel instead?

A subpanel adds circuit space, not capacity. If your total service is maxed out, you still need the main upgrade.

Home/Cost guides/Electrical Panel Upgrade/Aurora, IL

Chicago · Illinois

Electrical Panel Upgrade cost in Aurora, IL

Aurora homeowners typically pay $1,900 – $4,750 for electrical panel upgrade. Local labor and materials price 6% above the national average.

Get my Aurora estimate Use the Aurora calculator

Aurora average

$3,050

Typical low

$1,900

Typical high

$4,750

Per panel

$1,400 – $6,350

Sample ZIP

60505

What drives Aurora pricing

Local labor

Aurora is one of the more affordable Chicago-area submarkets.

Permits & code

City permits required for exterior and structural work.

Climate & conditions

Snow loads and freeze-thaw cycles affect roofs and driveways.

Instant cost calculator

Adjust the inputs to see live pricing

Panels to upgrade1 panel

Target service size

Service entrance

Panel location

Code corrections

Estimated project cost

$1,400 – $2,650

Most homeowners pay around $2,025

Compare target service size

Cost by material in Aurora

Installed Aurora pricing per panel.

Option	Installed cost	Pros	Cons
100 amp service	$1,400 – $2,650	Fine for small homes with gas heat	No headroom for EV or heat pump
150 amp service	$1,900 – $3,400	Middle ground	Often costs nearly the same as 200
200 amp service	$2,100 – $4,750	The modern standard, supports EV and electrification	May require new meter base
400 amp service	$4,250 – $9,550	Large homes, shops, multiple EVs	Utility coordination and two panels
Subpanel	$635 – $2,100	Cheap way to add circuits	Does not increase total service capacity

Where the money goes in Aurora

A typical $3,050 Aurora project, broken down by line item.

Labor48% · $1,464
Panel and breakers27% · $824
Service entrance materials15% · $458
Permits and inspection10% · $305

Common add-ons

Extras that show up on Aurora quotes but rarely in the headline price.

EV charger circuit

$530 – $2,100

Whole-home surge protector

$265 – $740

Generator interlock or transfer switch

$425 – $2,650

Grounding rod system update

$210 – $850

AFCI/GFCI breaker upgrades

Per breaker

$42 – $125

Ways to save in Aurora

Go straight to 200 amp — the incremental cost over 150 is small and you will not repeat the job.
Bundle EV charger, surge protector and any new circuits into the same permit and visit.
Check for utility and federal electrification rebates before you sign.
Get three bids; panel pricing varies more between electricians than almost any other trade.
Ask about keeping the panel in its existing location to avoid relocation cost.

Aurora FAQs

Get a Aurora price you can budget against

Answer a few questions about your project and we'll model a low, average and premium price for your IL ZIP code — then connect you with vetted local pros.

Get electrician quotes

More Aurora research

Best electrical panel upgrade companies in Aurora Electrical Panel Upgrade permits in Illinois Electrical Panel Upgrade near me All Illinois prices

Electrical Panel Upgrade cost near Aurora

Electrical Panel Upgrade cost in Chicago, IL

$2,043 – $5,108

Electrical Panel Upgrade cost in Naperville, IL

$2,008 – $5,019

Electrical Panel Upgrade cost in Evanston, IL

$2,079 – $5,198

Electrical Panel Upgrade cost in Schaumburg, IL

$1,954 – $4,884

Electrical Panel Upgrade cost in Joliet, IL

$1,864 – $4,660

Electrical Panel Upgrade cost in Elgin, IL

$1,882 – $4,705

More Illinois cities

Cicero Springfield Peoria Rockford Champaign

Other project costs in Aurora

Fence Installation in Aurora

$1,590 – $4,240

Roof Replacement in Aurora

$9,010 – $36,040

Kitchen Remodel in Aurora

$19,080 – $100,700

HVAC Replacement in Aurora

$5,830 – $19,080

Deck Building in Aurora

$4,664 – $12,720

Window Replacement in Aurora

$477 – $1,590

See every Aurora cost guide