How much does ductwork replacement cost in Dallas, TX?

Most Dallas homeowners spend between $3,850 – $9,200 on ductwork replacement, with an average around $6,500. Local labor prices 2% above the national average, so Dallas quotes tend to land at the higher end of national ranges.

Why is ductwork replacement more or less expensive in Dallas than elsewhere?

DFW has deep contractor supply, so bids stay close to the national average outside storm season. Hail and high winds drive frequent roof replacement and impact-rated material upgrades.

Do I need a permit for ductwork replacement in Dallas, Texas?

Dallas permits are required for roofing, structural, electrical and fences over 6 feet. Always confirm current requirements with the local building department before signing a contract, and make sure the permit is pulled by your licensed contractor.

How many quotes should I get in Dallas?

Get at least three written quotes from licensed, insured Texas contractors. Comparing line items — not just the bottom line — is the fastest way to spot an inflated bid in the Dallas-Fort Worth market.

How much does ductwork replacement cost in 2026?

Most homeowners pay between $3,750 and $9,000, with a national average near $6,375. Small, simple jobs land at the low end; large or premium-material jobs run well above the high end.

What is the cost per linear foot?

Installed pricing usually runs $25.00 to $60.00 per linear foot, including labor and materials. Expensive metros can run 15–45% higher than that range.

What drives the price up the most?

Scope and access. Larger quantities lower your per-linear foot price, but difficult access, demolition of existing work, structural repairs found mid-job, premium materials and rush scheduling each add 8–30%.

Permits are typically required when the work changes structure or ties into electrical, plumbing, gas or mechanical systems. Budget $75–$600 in most cities and confirm whether your contractor pulls it — unpermitted work can block a future home sale.

How long does the job take?

Most residential projects of this type finish in one to five working days once materials are on site. Custom orders, inspections and weather are the usual causes of delay.

How many quotes should I get?

Three. Bids on the same scope commonly vary 20–40%, and the middle bid with the strongest warranty and references is usually the best value — the cheapest bid often excludes prep, disposal or permits.

Home/Cost guides/Ductwork Replacement/Dallas, TX

Dallas-Fort Worth · Texas

Ductwork Replacement cost in Dallas, TX

Dallas homeowners typically pay $3,850 – $9,200 for ductwork replacement. Local labor and materials price 2% above the national average.

Get my Dallas estimate Use the Dallas calculator

Dallas average

$6,500

Typical low

$3,850

Typical high

$9,200

Per linear foot

$26 – $61

Sample ZIP

75201

What drives Dallas pricing

Local labor

DFW has deep contractor supply, so bids stay close to the national average outside storm season.

Permits & code

Dallas permits are required for roofing, structural, electrical and fences over 6 feet.

Climate & conditions

Hail and high winds drive frequent roof replacement and impact-rated material upgrades.

Instant cost calculator

Adjust the inputs to see live pricing

Duct run (linear feet)150 linear feet

Quality / material level

Site access

Removal / prep work

Timing

Estimated project cost

$3,848 – $5,273

Most homeowners pay around $4,560

Compare quality / material level

Cost by material in Dallas

Installed Dallas pricing per linear foot.

Option	Installed cost	Pros	Cons
Flexible duct	$27 – $37	—	—
Sheet metal trunk and flex runs	$37 – $49	—	—
Insulated sheet metal	$49 – $63	—	—
Custom sealed metal with zoning	$63 – $87	—	—

Where the money goes in Dallas

A typical $6,500 Dallas project, broken down by line item.

Labor0.45% · $29
Materials0.38% · $25
Permits & inspections0.05% · $3
Overhead & profit0.12% · $8

Common add-ons

Extras that show up on Dallas quotes but rarely in the headline price.

Duct sealing (Aeroseal)

$1,000 – $3,050

New returns

$305 – $1,200

Zoning dampers

$1,550 – $4,600

Asbestos duct wrap removal

$1,000 – $5,100

Ways to save in Dallas

Replace ducts while the system is being replaced — one mobilization.
Seal instead of replace when ducts are intact but leaky.
Collect three written bids on an identical scope — spreads of 20–40% are normal.
Book in the off-season and stay flexible on the start date to save 5–15%.
Bundle nearby work into one mobilization so you only pay setup and travel once.
Ask what the contractor would change to cut 10% without hurting durability.

Dallas FAQs

Get a Dallas price you can budget against

Answer a few questions about your project and we'll model a low, average and premium price for your TX ZIP code — then connect you with vetted local pros.

Get free quotes from certified pros

More Dallas research

Best ductwork replacement companies in Dallas Ductwork Replacement permits in Texas Ductwork Replacement near me All Texas prices

Ductwork Replacement cost near Dallas

Ductwork Replacement cost in Fort Worth, TX

$3,775 – $9,020

Ductwork Replacement cost in Plano, TX

$3,963 – $9,471

Ductwork Replacement cost in Frisco, TX

$4,001 – $9,561

Ductwork Replacement cost in Arlington, TX

$3,737 – $8,929

Ductwork Replacement cost in Irving, TX

$3,775 – $9,020

Ductwork Replacement cost in McKinney, TX

$3,925 – $9,380

More Texas cities

Denton Garland Houston Katy Sugar Land The Woodlands Pearland Pasadena

Other project costs in Dallas

Fence Installation in Dallas

$1,530 – $4,080

Roof Replacement in Dallas

$8,670 – $34,680

Kitchen Remodel in Dallas

$18,360 – $96,900

HVAC Replacement in Dallas

$5,610 – $18,360

Deck Building in Dallas

$4,488 – $12,240

Window Replacement in Dallas

$459 – $1,530

See every Dallas cost guide