How much does ductwork replacement cost in Spring, TX?

Most Spring homeowners spend between $3,750 – $9,000 on ductwork replacement, with an average around $6,400. Local labor prices right at the national average, so Spring quotes tend to land at the higher end of national ranges.

Why is ductwork replacement more or less expensive in Spring than elsewhere?

North Houston crews price at the metro average. Wet, humid conditions favor rot-resistant framing and decking.

Do I need a permit for ductwork replacement in Spring, Texas?

Harris County permits apply to most exterior work. Always confirm current requirements with the local building department before signing a contract, and make sure the permit is pulled by your licensed contractor.

How many quotes should I get in Spring?

Get at least three written quotes from licensed, insured Texas contractors. Comparing line items — not just the bottom line — is the fastest way to spot an inflated bid in the Houston market.

How much does ductwork replacement cost in 2026?

Most homeowners pay between $3,750 and $9,000, with a national average near $6,375. Small, simple jobs land at the low end; large or premium-material jobs run well above the high end.

What is the cost per linear foot?

Installed pricing usually runs $25.00 to $60.00 per linear foot, including labor and materials. Expensive metros can run 15–45% higher than that range.

What drives the price up the most?

Scope and access. Larger quantities lower your per-linear foot price, but difficult access, demolition of existing work, structural repairs found mid-job, premium materials and rush scheduling each add 8–30%.

Permits are typically required when the work changes structure or ties into electrical, plumbing, gas or mechanical systems. Budget $75–$600 in most cities and confirm whether your contractor pulls it — unpermitted work can block a future home sale.

How long does the job take?

Most residential projects of this type finish in one to five working days once materials are on site. Custom orders, inspections and weather are the usual causes of delay.

How many quotes should I get?

Three. Bids on the same scope commonly vary 20–40%, and the middle bid with the strongest warranty and references is usually the best value — the cheapest bid often excludes prep, disposal or permits.

Home/Cost guides/Ductwork Replacement/Spring, TX

Houston · Texas

Ductwork Replacement cost in Spring, TX

Spring homeowners typically pay $3,750 – $9,000 for ductwork replacement. Local labor and materials price right at the national average.

Get my Spring estimate Use the Spring calculator

Spring average

$6,400

Typical low

$3,750

Typical high

$9,000

Per linear foot

$25 – $60

Sample ZIP

77373

What drives Spring pricing

Local labor

North Houston crews price at the metro average.

Permits & code

Harris County permits apply to most exterior work.

Climate & conditions

Wet, humid conditions favor rot-resistant framing and decking.

Instant cost calculator

Adjust the inputs to see live pricing

Duct run (linear feet)150 linear feet

Quality / material level

Site access

Removal / prep work

Timing

Estimated project cost

$3,705 – $5,130

Most homeowners pay around $4,418

Compare quality / material level

Cost by material in Spring

Installed Spring pricing per linear foot.

Option	Installed cost	Pros	Cons
Flexible duct	$26 – $36	—	—
Sheet metal trunk and flex runs	$36 – $48	—	—
Insulated sheet metal	$48 – $62	—	—
Custom sealed metal with zoning	$62 – $85	—	—

Where the money goes in Spring

A typical $6,400 Spring project, broken down by line item.

Labor0.45% · $29
Materials0.38% · $24
Permits & inspections0.05% · $3
Overhead & profit0.12% · $8

Common add-ons

Extras that show up on Spring quotes but rarely in the headline price.

Duct sealing (Aeroseal)

$1,000 – $3,000

New returns

$300 – $1,200

Zoning dampers

$1,500 – $4,500

Asbestos duct wrap removal

$1,000 – $5,000

Ways to save in Spring

Replace ducts while the system is being replaced — one mobilization.
Seal instead of replace when ducts are intact but leaky.
Collect three written bids on an identical scope — spreads of 20–40% are normal.
Book in the off-season and stay flexible on the start date to save 5–15%.
Bundle nearby work into one mobilization so you only pay setup and travel once.
Ask what the contractor would change to cut 10% without hurting durability.

Spring FAQs

Get a Spring price you can budget against

Answer a few questions about your project and we'll model a low, average and premium price for your TX ZIP code — then connect you with vetted local pros.

Get free quotes from certified pros

More Spring research

Best ductwork replacement companies in Spring Ductwork Replacement permits in Texas Ductwork Replacement near me All Texas prices

Ductwork Replacement cost near Spring

Ductwork Replacement cost in Houston, TX

$3,750 – $9,000

Ductwork Replacement cost in Katy, TX

$3,863 – $9,270

Ductwork Replacement cost in Sugar Land, TX

$3,938 – $9,450

Ductwork Replacement cost in The Woodlands, TX

$4,013 – $9,630

Ductwork Replacement cost in Pearland, TX

$3,788 – $9,090

Ductwork Replacement cost in Pasadena, TX

$3,638 – $8,730

More Texas cities

Dallas Fort Worth Plano Frisco Arlington Irving McKinney Denton

Other project costs in Spring

Fence Installation in Spring

$1,500 – $4,000

Roof Replacement in Spring

$8,500 – $34,000

Kitchen Remodel in Spring

$18,000 – $95,000

HVAC Replacement in Spring

$5,500 – $18,000

Deck Building in Spring

$4,400 – $12,000

Window Replacement in Spring

$450 – $1,500

See every Spring cost guide