How much does ductwork replacement cost in Round Rock, TX?

Most Round Rock homeowners spend between $4,050 – $9,700 on ductwork replacement, with an average around $6,900. Local labor prices 8% above the national average, so Round Rock quotes tend to land at the higher end of national ranges.

Why is ductwork replacement more or less expensive in Round Rock than elsewhere?

Round Rock prices under central Austin but above the state average. Rocky soils raise the cost of post holes and footings.

Do I need a permit for ductwork replacement in Round Rock, Texas?

City permits and HOA review both apply. Always confirm current requirements with the local building department before signing a contract, and make sure the permit is pulled by your licensed contractor.

How many quotes should I get in Round Rock?

Get at least three written quotes from licensed, insured Texas contractors. Comparing line items — not just the bottom line — is the fastest way to spot an inflated bid in the Austin market.

How much does ductwork replacement cost in 2026?

Most homeowners pay between $3,750 and $9,000, with a national average near $6,375. Small, simple jobs land at the low end; large or premium-material jobs run well above the high end.

What is the cost per linear foot?

Installed pricing usually runs $25.00 to $60.00 per linear foot, including labor and materials. Expensive metros can run 15–45% higher than that range.

What drives the price up the most?

Scope and access. Larger quantities lower your per-linear foot price, but difficult access, demolition of existing work, structural repairs found mid-job, premium materials and rush scheduling each add 8–30%.

Permits are typically required when the work changes structure or ties into electrical, plumbing, gas or mechanical systems. Budget $75–$600 in most cities and confirm whether your contractor pulls it — unpermitted work can block a future home sale.

How long does the job take?

Most residential projects of this type finish in one to five working days once materials are on site. Custom orders, inspections and weather are the usual causes of delay.

How many quotes should I get?

Three. Bids on the same scope commonly vary 20–40%, and the middle bid with the strongest warranty and references is usually the best value — the cheapest bid often excludes prep, disposal or permits.

Home/Cost guides/Ductwork Replacement/Round Rock, TX

Austin · Texas

Ductwork Replacement cost in Round Rock, TX

Round Rock homeowners typically pay $4,050 – $9,700 for ductwork replacement. Local labor and materials price 8% above the national average.

Get my Round Rock estimate Use the Round Rock calculator

Round Rock average

$6,900

Typical low

$4,050

Typical high

$9,700

Per linear foot

$27 – $65

Sample ZIP

78664

What drives Round Rock pricing

Local labor

Round Rock prices under central Austin but above the state average.

Permits & code

City permits and HOA review both apply.

Climate & conditions

Rocky soils raise the cost of post holes and footings.

Instant cost calculator

Adjust the inputs to see live pricing

Duct run (linear feet)150 linear feet

Quality / material level

Site access

Removal / prep work

Timing

Estimated project cost

$3,990 – $5,558

Most homeowners pay around $4,774

Compare quality / material level

Cost by material in Round Rock

Installed Round Rock pricing per linear foot.

Option	Installed cost	Pros	Cons
Flexible duct	$28 – $39	—	—
Sheet metal trunk and flex runs	$39 – $51	—	—
Insulated sheet metal	$51 – $67	—	—
Custom sealed metal with zoning	$67 – $92	—	—

Where the money goes in Round Rock

A typical $6,900 Round Rock project, broken down by line item.

Labor0.45% · $31
Materials0.38% · $26
Permits & inspections0.05% · $3
Overhead & profit0.12% · $8

Common add-ons

Extras that show up on Round Rock quotes but rarely in the headline price.

Duct sealing (Aeroseal)

$1,100 – $3,250

New returns

$325 – $1,300

Zoning dampers

$1,600 – $4,850

Asbestos duct wrap removal

$1,100 – $5,400

Ways to save in Round Rock

Replace ducts while the system is being replaced — one mobilization.
Seal instead of replace when ducts are intact but leaky.
Collect three written bids on an identical scope — spreads of 20–40% are normal.
Book in the off-season and stay flexible on the start date to save 5–15%.
Bundle nearby work into one mobilization so you only pay setup and travel once.
Ask what the contractor would change to cut 10% without hurting durability.

Round Rock FAQs

Get a Round Rock price you can budget against

Answer a few questions about your project and we'll model a low, average and premium price for your TX ZIP code — then connect you with vetted local pros.

Get free quotes from certified pros

More Round Rock research

Best ductwork replacement companies in Round Rock Ductwork Replacement permits in Texas Ductwork Replacement near me All Texas prices

Ductwork Replacement cost near Round Rock

Ductwork Replacement cost in Austin, TX

$4,200 – $10,059

Ductwork Replacement cost in Cedar Park, TX

$4,088 – $9,790

Ductwork Replacement cost in Georgetown, TX

$3,975 – $9,520

Ductwork Replacement cost in San Marcos, TX

$3,900 – $9,341

Ductwork Replacement cost in Pflugerville, TX

$4,012 – $9,610

More Texas cities

Dallas Fort Worth Plano Frisco Arlington Irving McKinney Denton

Other project costs in Round Rock

Fence Installation in Round Rock

$1,620 – $4,320

Roof Replacement in Round Rock

$9,180 – $36,720

Kitchen Remodel in Round Rock

$19,440 – $102,600

HVAC Replacement in Round Rock

$5,940 – $19,440

Deck Building in Round Rock

$4,752 – $12,960

Window Replacement in Round Rock

$486 – $1,620

See every Round Rock cost guide