How much does ductwork replacement cost in San Marcos, TX?

Most San Marcos homeowners spend between $3,900 – $9,350 on ductwork replacement, with an average around $6,650. Local labor prices 4% above the national average, so San Marcos quotes tend to land at the higher end of national ranges.

Why is ductwork replacement more or less expensive in San Marcos than elsewhere?

San Marcos labor is cheaper than Austin with reasonable availability. Flash-flood exposure affects drainage and site work.

Do I need a permit for ductwork replacement in San Marcos, Texas?

City permits apply to most exterior and structural work. Always confirm current requirements with the local building department before signing a contract, and make sure the permit is pulled by your licensed contractor.

How many quotes should I get in San Marcos?

Get at least three written quotes from licensed, insured Texas contractors. Comparing line items — not just the bottom line — is the fastest way to spot an inflated bid in the Austin market.

How much does ductwork replacement cost in 2026?

Most homeowners pay between $3,750 and $9,000, with a national average near $6,375. Small, simple jobs land at the low end; large or premium-material jobs run well above the high end.

What is the cost per linear foot?

Installed pricing usually runs $25.00 to $60.00 per linear foot, including labor and materials. Expensive metros can run 15–45% higher than that range.

What drives the price up the most?

Scope and access. Larger quantities lower your per-linear foot price, but difficult access, demolition of existing work, structural repairs found mid-job, premium materials and rush scheduling each add 8–30%.

Permits are typically required when the work changes structure or ties into electrical, plumbing, gas or mechanical systems. Budget $75–$600 in most cities and confirm whether your contractor pulls it — unpermitted work can block a future home sale.

How long does the job take?

Most residential projects of this type finish in one to five working days once materials are on site. Custom orders, inspections and weather are the usual causes of delay.

How many quotes should I get?

Three. Bids on the same scope commonly vary 20–40%, and the middle bid with the strongest warranty and references is usually the best value — the cheapest bid often excludes prep, disposal or permits.

Home/Cost guides/Ductwork Replacement/San Marcos, TX

Austin · Texas

Ductwork Replacement cost in San Marcos, TX

San Marcos homeowners typically pay $3,900 – $9,350 for ductwork replacement. Local labor and materials price 4% above the national average.

Get my San Marcos estimate Use the San Marcos calculator

San Marcos average

$6,650

Typical low

$3,900

Typical high

$9,350

Per linear foot

$26 – $62

Sample ZIP

78666

What drives San Marcos pricing

Local labor

San Marcos labor is cheaper than Austin with reasonable availability.

Permits & code

City permits apply to most exterior and structural work.

Climate & conditions

Flash-flood exposure affects drainage and site work.

Instant cost calculator

Adjust the inputs to see live pricing

Duct run (linear feet)150 linear feet

Quality / material level

Site access

Removal / prep work

Timing

Estimated project cost

$3,848 – $5,415

Most homeowners pay around $4,631

Compare quality / material level

Cost by material in San Marcos

Installed San Marcos pricing per linear foot.

Option	Installed cost	Pros	Cons
Flexible duct	$27 – $38	—	—
Sheet metal trunk and flex runs	$38 – $50	—	—
Insulated sheet metal	$50 – $64	—	—
Custom sealed metal with zoning	$64 – $88	—	—

Where the money goes in San Marcos

A typical $6,650 San Marcos project, broken down by line item.

Labor0.45% · $30
Materials0.38% · $25
Permits & inspections0.05% · $3
Overhead & profit0.12% · $8

Common add-ons

Extras that show up on San Marcos quotes but rarely in the headline price.

Duct sealing (Aeroseal)

$1,050 – $3,100

New returns

$310 – $1,250

Zoning dampers

$1,550 – $4,700

Asbestos duct wrap removal

$1,050 – $5,200

Ways to save in San Marcos

Replace ducts while the system is being replaced — one mobilization.
Seal instead of replace when ducts are intact but leaky.
Collect three written bids on an identical scope — spreads of 20–40% are normal.
Book in the off-season and stay flexible on the start date to save 5–15%.
Bundle nearby work into one mobilization so you only pay setup and travel once.
Ask what the contractor would change to cut 10% without hurting durability.

San Marcos FAQs

Get a San Marcos price you can budget against

Answer a few questions about your project and we'll model a low, average and premium price for your TX ZIP code — then connect you with vetted local pros.

Get free quotes from certified pros

More San Marcos research

Best ductwork replacement companies in San Marcos Ductwork Replacement permits in Texas Ductwork Replacement near me All Texas prices

Ductwork Replacement cost near San Marcos

Ductwork Replacement cost in Austin, TX

$4,200 – $10,069

Ductwork Replacement cost in Round Rock, TX

$4,050 – $9,710

Ductwork Replacement cost in Cedar Park, TX

$4,088 – $9,800

Ductwork Replacement cost in Georgetown, TX

$3,975 – $9,530

Ductwork Replacement cost in Pflugerville, TX

$4,013 – $9,620

More Texas cities

Dallas Fort Worth Plano Frisco Arlington Irving McKinney Denton

Other project costs in San Marcos

Fence Installation in San Marcos

$1,560 – $4,160

Roof Replacement in San Marcos

$8,840 – $35,360

Kitchen Remodel in San Marcos

$18,720 – $98,800

HVAC Replacement in San Marcos

$5,720 – $18,720

Deck Building in San Marcos

$4,576 – $12,480

Window Replacement in San Marcos

$468 – $1,560

See every San Marcos cost guide